Sub-orbital spaceflight
A sub-orbital spaceflight is a spaceflight in which the spacecraft reaches outer space, but its trajectory intersects the surface of the gravitating body from which it was launched. Hence, it will not complete one orbital revolution, will not become an artificial satellite nor will it reach escape velocity.
For example, the path of an object launched from Earth that reaches the Kármán line, and then falls back to Earth, is considered a sub-orbital spaceflight. Some sub-orbital flights have been undertaken to test spacecraft and launch vehicles later intended for orbital spaceflight. Other vehicles are specifically designed only for sub-orbital flight; examples include crewed vehicles, such as the X-15 and SpaceShipTwo, and uncrewed ones, such as ICBMs and sounding rockets.
Flights which attain sufficient velocity to go into low Earth orbit, and then de-orbit before completing their first full orbit, are not considered sub-orbital. Examples of this include flights of the Fractional Orbital Bombardment System.
A flight that does not reach space is still sometimes called sub-orbital, but cannot officially be classified as a "sub-orbital spaceflight". Usually a rocket is used, but some experimental sub-orbital spaceflights have also been achieved via the use of space guns.
Altitude requirement
[Image:Newton Cannon.svg|thumb|right|Isaac Newton's Cannonball. Paths A and B depict a sub-orbital trajectory.]By definition, a sub-orbital spaceflight reaches an altitude higher than above sea level. This altitude, known as the Kármán line, was chosen by the Fédération Aéronautique Internationale because it is roughly the point where a vehicle flying fast enough to support itself with aerodynamic lift from the Earth's atmosphere would be flying faster than orbital speed. The US military and NASA award astronaut wings to those flying above, although the U.S. State Department does not show a distinct boundary between atmospheric flight and spaceflight.
Orbit
During freefall the trajectory is part of an elliptic orbit as given by the orbit equation. The perigee distance is less than the radius of the Earth R including atmosphere, hence the ellipse intersects the Earth, and hence the spacecraft will fail to complete an orbit. The major axis is vertical, the semi-major axis a is more than R/2. The specific orbital energy is given by:where is the standard gravitational parameter.
Almost always a < R, corresponding to a lower than the minimum for a full orbit, which is
Thus the net extra specific energy needed compared to just raising the spacecraft into space is between 0 and.
Speed, range, and altitude
To minimize the required delta-v, the high-altitude part of the flight is made with the rockets off. The maximum speed in a flight is attained at the lowest altitude of this free-fall trajectory, both at the start and at the end of it.If one's goal is simply to "reach space", for example in competing for the Ansari X Prize, horizontal motion is not needed. In this case the lowest required delta-v, to reach 100 km altitude, is about 1.4 km/s. Moving slower, with less free-fall, would require more delta-v.
Compare this with orbital spaceflights: a low Earth orbit, with an altitude of about 300 km, needs a speed around 7.7 km/s, requiring a delta-v of about 9.2 km/s.
For sub-orbital spaceflights covering a horizontal distance the maximum speed and required delta-v are in between those of a vertical flight and a LEO. The maximum speed at the lower ends of the trajectory are now composed of a horizontal and a vertical component. The higher the horizontal distance covered, the greater the horizontal speed will be. For the V-2 rocket, just reaching space but with a range of about 330 km, the maximum speed was 1.6 km/s. Scaled Composites SpaceShipTwo which is under development will have a similar free-fall orbit but the announced maximum speed is 1.1 km/s.
For larger ranges, due to the elliptic orbit the maximum altitude can be much more than for a LEO. On a 10,000-kilometer intercontinental flight, such as that of an intercontinental ballistic missile or possible future commercial spaceflight, the maximum speed is about 7 km/s, and the maximum altitude may be more than 1300 km.
Any spaceflight that returns to the surface, including sub-orbital ones, will undergo atmospheric reentry. The speed at the start of the reentry is basically the maximum speed of the flight. The aerodynamic heating caused will vary accordingly: it is much less for a flight with a maximum speed of only 1 km/s than for one with a maximum speed of 7 or 8 km/s.
The minimum delta-v and the corresponding maximum altitude for a given range can be calculated, d, assuming a spherical Earth of circumference and neglecting the Earth's rotation and atmosphere. Let θ be half the angle that the projectile is to go around the Earth, so in degrees it is 45°×d/. The minimum-delta-v trajectory corresponds to an ellipse with one focus at the centre of the Earth and the other at the point halfway between the launch point and the destination point. Geometrical arguments lead then to the following :
The altitude of apogee is maximized for a trajectory going one quarter of the way around the Earth. Longer ranges will have lower apogees in the minimal-delta-v solution.
. The Δv increases with range, leveling off at 7.9 km/s as the range approaches . The minimum-delta-v trajectory for going halfway around the world corresponds to a circular orbit just above the surface. See lower for the time of flight.
An intercontinental ballistic missile is defined as a missile that can hit a target at least 5500 km away, and according to the above formula this requires an initial speed of 6.1 km/s. Increasing the speed to 7.9 km/s to attain any point on Earth requires a considerably larger missile because the amount of fuel needed goes up exponentially with delta-v.
The initial direction of a minimum-delta-v trajectory points halfway between straight up and straight toward the destination point. Again, this is the case if the Earth's rotation is ignored. It is not exactly true for a rotating planet unless the launch takes place at a pole.
Flight duration
In a vertical flight of not too high altitudes, the time of the free-fall is both for the upward and for the downward part the maximum speed divided by the acceleration of gravity, so with a maximum speed of 1 km/s together 3 minutes and 20 seconds. The duration of the flight phases before and after the free-fall can vary.For an intercontinental flight the boost phase takes 3 to 5 minutes, the free-fall about 25 minutes. For an ICBM the atmospheric reentry phase takes about 2 minutes; this will be longer for any soft landing, such as for a possible future commercial flight. Test flight 4 of the SpaceX 'Starship' performed such a flight with a lift off from Texas and a simulated soft touchdown in the Indian Ocean 66 minutes after liftoff.
Sub-orbital flights can last from just seconds to days. Pioneer 1 was NASA's first space probe, intended to reach the Moon. A partial failure caused it to instead follow a sub-orbital trajectory, reentering the Earth's atmosphere 43 hours after launch.
To calculate the time of flight for a minimum-delta-v trajectory, according to Kepler's third law, the period for the entire orbit would be:
Using Kepler's second law, we multiply this by the portion of the area of the ellipse swept by the line from the centre of the Earth to the projectile:
This gives about 32 minutes for going a quarter of the way around the Earth, and 42 minutes for going halfway around. For short distances, this expression is asymptotic to.
From the form involving arccosine, the derivative of the time of flight with respect to d goes to zero as d approaches . The derivative of Δv also goes to zero here. So if d =, the length of the minimum-delta-v trajectory will be about, but it will take only a few seconds less time than the trajectory for d = .
Flight profiles
While there are a great many possible sub-orbital flight profiles, it is expected that some will be more common than others.Ballistic missiles
The first sub-orbital vehicles which reached space were ballistic missiles. The first ballistic missile to reach space was the German V-2, the work of the scientists at Peenemünde, on October 3, 1942, which reached an altitude of. Then in the late 1940s the US and USSR concurrently developed missiles all of which were based on the V-2 Rocket, and then much longer range Intercontinental Ballistic Missiles. There are now many countries who possess ICBMs and even more with shorter range Intermediate Range Ballistic Missiles.Tourist flights
Sub-orbital tourist flights will initially focus on attaining the altitude required to qualify as reaching space. The flight path will be either vertical or very steep, with the spacecraft landing back at its take-off site.The spacecraft will shut off its engines well before reaching maximum altitude, and then coast up to its highest point. During a few minutes, from the point when the engines are shut off to the point where the atmosphere begins to slow down the downward acceleration, the passengers will experience weightlessness.
Megaroc had been planned for sub-orbital spaceflight by the British Interplanetary Society in the 1940s.
In late 1945, a group led by M. Tikhonravov K. and N. G. Chernysheva at the Soviet NII-4 academy, began work on a stratospheric rocket project, VR-190, aimed at vertical flight by a crew of two pilots, to an altitude of 200 km using captured V-2.
In 2004, a number of companies worked on vehicles in this class as entrants to the Ansari X Prize competition. The Scaled Composites SpaceShipOne was officially declared by Rick Searfoss to have won the competition on October 4, 2004, after completing two flights within a two-week period.
In 2005, Sir Richard Branson of the Virgin Group announced the creation of Virgin Galactic and his plans for a 9-seat capacity SpaceShipTwo named VSS Enterprise. It has since been completed with eight seats and has taken part in captive-carry tests and with the first mother-ship WhiteKnightTwo, or VMS Eve. It has also completed solitary glides, with the movable tail sections in both fixed and "feathered" configurations. The hybrid rocket motor has been fired multiple times in ground-based test stands, and was fired in a powered flight for the second time on 5 September 2013. Four additional SpaceShipTwos have been ordered and will operate from the new Spaceport America. Commercial flights carrying passengers were expected in 2014, but became cancelled due to the disaster during SS2 PF04 flight. Branson stated, "e are going to learn from what went wrong, discover how we can improve safety and performance and then move forwards together."
Scientific experiments
A major use of sub-orbital vehicles today is as scientific sounding rockets. Scientific sub-orbital flights began in the 1920s when Robert H. Goddard launched the first liquid fueled rockets, however they did not reach space altitude. In the late 1940s, captured German V-2 ballistic missiles were converted into V-2 sounding rockets which helped lay the foundation for modern sounding rockets. Today there are dozens of different sounding rockets on the market, from a variety of suppliers in various countries. Typically, researchers wish to conduct experiments in microgravity or above the atmosphere.Sub-orbital transportation
Research, such as that done for the X-20 Dyna-Soar project suggests that a semi-ballistic sub-orbital flight could travel from Europe to North America in less than an hour.However, the size of rocket, relative to the payload, necessary to achieve this, is similar to an ICBM. ICBMs have delta-v's somewhat less than orbital; and therefore would be somewhat cheaper than the costs for reaching orbit, but the difference is not large.
Due to the high cost of spaceflight, suborbital flights are likely to be initially limited to high value, very high urgency cargo deliveries such as courier flights, military fast-response operations or space tourism.
The SpaceLiner is a hypersonic suborbital spaceplane concept that could transport 50 passengers from Australia to Europe in 90 minutes or 100 passengers from Europe to California in 60 minutes. The main challenge lies in increasing the reliability of the different components, particularly the engines, in order to make their use for passenger transportation on a daily basis possible.
SpaceX is potentially considering using their Starship as a sub-orbital point-to-point transportation system.
Notable uncrewed sub-orbital spaceflights
- The first sub-orbital space flight was on 20 June 1944, when MW 18014, a V-2 test rocket, launched from Peenemünde in Germany and reached 176 kilometres altitude.
- Bumper 5, a two-stage rocket launched from the White Sands Proving Grounds. On 24 February 1949 the upper stage reached an altitude of and a speed of.
- Albert II, a male rhesus macaque, became the first mammal in space on 14 June 1949 in a sub-orbital flight from Holloman Air Force Base in New Mexico to an altitude of 83 miles aboard a U.S. V-2 sounding rocket.
- USSR – Energia, 15 May 1987, a Polyus payload which failed to reach orbit
- SpaceX IFT-7, 16 January 2025, a Starship flight test which blew up during ascent, forcing airline flights to alter course to avoid falling debris and setting back Elon Musk's flagship rocket program. There were also numerous reports of damage on the ground. It is, to date, the most massive object launched into a sub-orbital trajectory.
Crewed sub-orbital spaceflights
Above 100 km in altitude.| Date | Mission | Crew | Country | Remarks | |
| 1 | 1961-05-05 | Mercury-Redstone 3 | Alan Shepard | First crewed sub-orbital spaceflight, first American in space | |
| 2 | 1961-07-21 | Mercury-Redstone 4 | Virgil Grissom | Second crewed sub-orbital spaceflight, second American in space | |
| 3 | 1963-07-19 | X-15 Flight 90 | Joseph A. Walker | First winged craft in space | |
| 4 | 1963-08-22 | X-15 Flight 91 | Joseph A. Walker | First person and spacecraft to make two flights into space | |
| 5 | 1975-04-05 | Soyuz 18a | Vasili Lazarev Oleg Makarov | Failed orbital launch. Aborted after malfunction during stage separation | |
| 6 | 2004-06-21 | SpaceShipOne flight 15P | Mike Melvill | First commercial spaceflight | |
| 7 | 2004-09-29 | SpaceShipOne flight 16P | Mike Melvill | First of two flights to win Ansari X-Prize | |
| 8 | 2004-10-04 | SpaceShipOne flight 17P | Brian Binnie | Second X-Prize flight, clinching award | |
| 9 | 2021-07-20 | Blue Origin NS-16 | Jeff Bezos Mark Bezos Wally Funk Oliver Daemen | First crewed Blue Origin flight | |
| 10 | 2021-10-13 | Blue Origin NS-18 | Audrey Powers Chris Boshuizen Glen de Vries William Shatner | Second crewed Blue Origin flight | |
| 11 | 2021-12-11 | Blue Origin NS-19 | Michael Strahan Dylan Taylor Evan Dick Lane Bess Cameron Bess | Third crewed Blue Origin flight | |
| 12 | 2022-03-31 | Blue Origin NS-20 | Sharon Hagle Marc Hagle Jim Kitchen George Nield Gary Lai | Fourth crewed Blue Origin flight | |
| 13 | 2022-06-04 | Blue Origin NS-21 | Evan Dick Katya Echazarreta Hamish Harding Victor Correa Hespanha Jaison Robinson Victor Vescovo | Fifth crewed Blue Origin flight | |
| 14 | 2022-08-04 | Blue Origin NS-22 | Coby Cotton Mário Ferreira Vanessa O'Brien Clint Kelly III Sara Sabry Steve Young | Sixth crewed Blue Origin flight | |
| 15 | 2024-05-19 | Blue Origin NS-25 | Mason Angel Sylvain Chiron Ed Dwight Kenneth Hess Carol Schaller Gopichand Thotakura | Seventh crewed Blue Origin flight | |
| 16 | 2024-08-29 | Blue Origin NS-26 | Nicolina Elrick Rob Ferl Eugene Grin Eiman Jahangir Karsen Kitchen Ephraim Rabin | Eighth crewed Blue Origin flight | |
| 17 | 2024-11-22 | Blue Origin NS-28 | Henry Wolfond Austin Litteral James (J.D.) Russell Sharon Hagle Marc Hagle Emily Calandrelli | Ninth crewed Blue Origin flight | |
| 18 | 2025-02-25 | Blue Origin NS-30 | Lane Bess Jesús Calleja Tushar Shah Richard Scott Elaine Chia Hyde Russell Wilson | Tenth crewed Blue Origin flight | |
| 19 | 2025-04-14 | Blue Origin NS-31 | Aisha Bowe Amanda Nguyen Gayle King Katy Perry Lauren Sánchez Kerianne Flynn | Eleventh crewed Blue Origin flight. All female crew. | |
| 20 | 2025-05-31 | Blue Origin NS-32 | Dr. Gretchen Green Jesse Williams Aymette Medina Jorge Paul Jeris Jaime Alemán Mark Rocket | Twelfth crewed Blue Origin flight. | |
| 21 | 2025-06-29 | Blue Origin NS-33 | Thirteenth crewed Blue Origin flight. | ||
| 22 | 2025-08-03 | Blue Origin NS-34 | Fourteenth crewed Blue Origin flight. | ||
| 23 | 2025-10-08 | Blue Origin NS-36 | Fifteenth crewed Blue Origin flight. |
Crewed vertically-launched suborbital flights
Most manned rocket flights were either orbital spaceflights or flights of rocket-powered aircraft, which were launched horizontally. Manned vertically launched suborbital flights were before the first launch of New Shepard rare and often the result of a failure of a manned rocket for orbital spaceflight. The following list shows all manned vertically launched suborbital rocket flights.| Date | Mission | Crew | Launch vehicle | Apogee | Country | Remarks |
| 1961-05-05 | Mercury-Redstone 3 | Alan Shepard | Mercury-Redstone Launch Vehicle | 187.5 km | first American in space | |
| 1961-07-21 | Mercury-Redstone 4 | Virgil Grissom | Mercury-Redstone Launch Vehicle | 190.3 km | second American in space | |
| 1975-04-05 | Soyuz 18a | Vasili Lazarev Oleg Makarov | Soyuz | 192 km | Failed orbital launch. Aborted after malfunction during stage separation | |
| 1983-09-26 | Soyuz 7K-ST No.16L | Vladimir Titov Gennadi Strekalov | Soyuz | 0.65 km | Launch abort | |
| 1986-01-28 | STS-25 | Francis R. "Dick" Scobee Michael J. Smith Ellison S. Onizuka Judith A. Resnik Ronald E. McNair Gregory B. Jarvis S. Christa McAuliffe | Space Shuttle Challenger | 20 km | Space Shuttle Challenger disaster, all astronauts on board were killed | |
| 2014-01-30 | Hughes 1 | Mike Hughes | self-built rocket | 0.419 km | Mike Hughes got injured | |
| 2018-03-24 | Hughes 2 | Mike Hughes | self-built rocket | 0.572 km | ||
| 2018-10-11 | Soyuz MS-10 | Aleksey Ovchinin Nick Hague | Soyuz | 93 km | Failed orbital launch | |
| 2020-02-22 | Hughes 3 | Mike Hughes | self-built rocket | 1.5 km | Mike Hughes killed at crash landing as parachute was destroyed at launch | |
| 2021-07-20 | Blue Origin NS-16 | Jeff Bezos Mark Bezos Wally Funk Oliver Daemen | New Shepard | 107 km | First crewed Blue Origin flight | |
| 2021-10-13 | Blue Origin NS-18 | Audrey Powers Chris Boshuizen Glen de Vries William Shatner | New Shepard | 107 km | Second crewed Blue Origin flight | |
| 2021-12-11 | Blue Origin NS-19 | Michael Strahan Dylan Taylor Evan Dick Lane Bess Cameron Bess | New Shepard | 107 km | Third crewed Blue Origin flight | |
| 2022-03-31 | Blue Origin NS-20 | Sharon Hagle Marc Hagle Jim Kitchen George Nield Gary Lai | New Shepard | 107 km | Fourth crewed Blue Origin flight | |
| 2022-06-04 | Blue Origin NS-21 | Evan Dick Katya Echazarreta Hamish Harding Victor Correa Hespanha Jaison Robinson Victor Vescovo | New Shepard | 107 km | Fifth crewed Blue Origin flight | |
| 2022-08-04 | Blue Origin NS-22 | Coby Cotton Mário Ferreira Vanessa O'Brien Clint Kelly III Sara Sabry Steve Young | New Shepard | 107 km | Sixth crewed Blue Origin flight | |
| 2024-05-19 | Blue Origin NS-25 | Mason Angel Sylvain Chiron Ed Dwight Kenneth Hess Carol Schaller Gopichand Thotakura | New Shepard | 107 km | Seventh crewed Blue Origin flight | |
| 2024-08-29 | Blue Origin NS-26 | Nicolina Elrick Rob Ferl Eugene Grin Eiman Jahangir Karsen Kitchen Ephraim Rabin | New Shepard | 105 km | Eighth crewed Blue Origin flight | |
| 2024-11-22 | Blue Origin NS-28 | Henry Wolfond Austin Litteral James (J.D.) Russell Sharon Hagle Marc Hagle Emily Calandrelli | New Shepard | 107 km | Ninth crewed Blue Origin flight | |
| 2025-02-25 | Blue Origin NS-30 | Lane Bess Jesús Calleja Tushar Shah Richard Scott Elaine Chia Hyde Russell Wilson | New Shepard | 107 km | Tenth crewed Blue Origin flight | |
| 2025-04-14 | Blue Origin NS-31 | Aisha Bowe Amanda Nguyen Gayle King Katy Perry Lauren Sánchez Kerianne Flynn | New Shepard | 106 km | Eleventh crewed Blue Origin flight | |
| 2025-05-31 | Blue Origin NS-32 | Dr. Gretchen Green Jesse Williams Aymette Medina Jorge Paul Jeris Jaime Alemán Mark Rocket | New Shepard | 104 km | Twelfth crewed Blue Origin flight. | |
| 2025-06-29 | Blue Origin NS-33 | New Shepard | 106 km | Thirtheenth crewed Blue Origin flight. | ||
| 2025-08-03 | Blue Origin NS-34 | New Shepard | 104 km | Fourteenth crewed Blue Origin flight. | ||
| 2025-10-08 | Blue Origin NS-36 | New Shepard | 107 km | Fifteenth crewed Blue Origin flight. |
Future of crewed sub-orbital spaceflight
Private companies such as Virgin Galactic, Armadillo Aerospace, Airbus, Blue Origin and Masten Space Systems are taking an interest in sub-orbital spaceflight, due in part to ventures like the Ansari X Prize. NASA and others are experimenting with scramjet-based hypersonic aircraft which may well be used with flight profiles that qualify as sub-orbital spaceflight. Non-profit entities like ARCASPACE and Copenhagen Suborbitals also attempt rocket-based launches.Suborbital spaceflight projects
- Canadian Arrow
- CORONA
- DH-1 (rocket)
- Interorbital Systems
- Lunar Lander Challenge
- McDonnell Douglas DC-X
- Project Morpheus NASA program to continue developing ALHAT and Q landers
- Quad (rocket)
- Reusable Vehicle Testing program by JAXA
- Rocketplane XP
- SpaceX reusable launch system development program
- XCOR Lynx