Eurotunnel Class 9
The Eurotunnel Class 9 or Class 9000 are six-axle high-power Bo′Bo′Bo′ single-ended electric locomotives built by the Euroshuttle Locomotive Consortium of Brush Traction and ABB. The class was designed for and is used exclusively to haul the LeShuttle road vehicle services through the Channel Tunnel.
Background and design
Tendering for the locomotive procurement began in 1989. The specification included; a top speed of ; a terminal-to-terminal travel time of 33 minutes pulling a train; an axle load limit of ; an operating temperature range between and ; a loading gauge within the UIC 505-1 standard; a minimum curve radius of ; be able to start a shuttle train on a 1 in 160 gradient with one locomotive bogie inoperative, and a single locomotive should be able to start the train on the same gradient if the other locomotive failed. The operating concession agreement between the tunnel operator and the British and French governments required that there be a locomotive on either end of the train, allowing the reversing or splitting of the train in an emergency.The design specifications implied a minimum power of, and also meant that a four-axle design would not be guaranteed to be able to supply sufficient tractive effort. ESCL proposed a six-axle Bo′Bo′Bo′ locomotive derived from the narrow-gauge EF class locomotives supplied by Brush Traction to the New Zealand Railways Corporation and won the contract with an initial order of 40 in July 1989.
The main traction electrical system consists of: two pantographs collecting a 25 kV AC supply which feeds the main transformer, with separate output windings rectified to a DC link using four quadrant converters. The direct current drives a three-phase inverter, which powers two asynchronous three-phase induction motors. There are two additional output windings on the transformer for the locomotive's auxiliaries and to supply power to the train vehicles.
The bogies were a fabricated steel design, with coil spring primary suspension. The traction motors and gearboxes were mounted to the bogie frame and connected to the wheels by a flexibly coupled quill drive. Traction links were connected to the bogie frame at a height of above rail. The locomotive superstructure is supported on coil springs on a central swing bolster, and the centre bogie allows of lateral movement to negotiate small-radius curves. Yaw dampers are also fitted.
The locomotive superstructure is a stressed-skin monocoque design. Both the bogies and superstructures were fabricated by Qualter, Hall and Company of Barnsley.
The driver's cab and exterior design of the locomotives was undertaken by DCA Design. Side windows in the locomotive cab are omitted to prevent 'segment flicker' caused by fast running in the tunnel, a potential distraction and cause of operator drowsiness. The operator's cabin is air conditioned and pressurised for comfort. The locomotive uses in-cab TVM 430 signalling. The driving cab also incorporates train manager's facilities, including safety systems such as CCTV, alarms and communication links. There is a second driving position for shunting at the rear of the locomotive.
Testing and operations
The initial order for 40 units was reduced to 38, numbered 9001 to 9038. The first locomotive was completed in 1992, and two units were tested at the Velim test track in the Czech Republic. Locomotive 9004 started its required 50,000-kilometre endurance test at Velim on 17 August 1993 and finished it on 23 September 1993.The locomotives are maintained at the Eurotunnel depot located just beside Eurotunnel Calais Terminal at Coquelles near Calais, France.
The formal opening took place on 6 May 1994 with Queen Elizabeth II and François Mitterrand travelling on a shuttle through the tunnel.
The 1996 Channel Tunnel fire damaged locomotive 9030 beyond repair. It was scrapped in 1997 at the Coquelles depot.
Later subclasses
9100 subseries
In 1997, Eurotunnel ordered five more locomotives and in 1998 the order was increased to a total of 14. This second batch of locomotives also had small improvements compared to the originals, including IGBT-based traction inverters instead of GTO-based and one inverter per motor instead of one per bogie.This second batch of locomotives is numbered in the 9100 series except for one locomotive, 9040 which was purchased as a replacement for 9030, the locomotive destroyed in the 1996 fire.
9700 subseries
In 1999, Eurotunnel ordered seven locomotives with an increased power of. This third batch of locomotives was delivered between 2001 and 2003, and is numbered in the 9700 series. The higher power output allowed an increase in the length and weight of cargo shuttle trains.9800 subseries
Since 2000, Eurotunnel has been slowly rebuilding the older 9000 and 9100 series locomotives from, replacing the main transformer, traction converters and motors. These rebuilt locomotives are numbered in the 9800 series.By late 2017 of the 57 locomotives, 45 of them had been upgraded to the standard, while the remaining 12 had the original power.
| Number range | Built | Power | Notes |
| 9001–9038 | 1992–1994 | 9030 withdrawn due to fire damage | |
| 9040 | 1998 | Built to replace fire-damaged locomotive 9030 | |
| 9101–9113 | 1998–2001 | Dedicated to freight shuttles | |
| 9701–9707 | 2001–2002 | Dedicated to freight shuttles | |
| 9801– | Rebuilt 2004–2012 | Rebuilt from machines |
Names
After introduction the locomotives were named after opera singers. In 1997 four units were named Jungfraujoch, Lötschberg, Gotthard and Furkatunnel, after Swiss rail tunnels.| Number | Name |
| 9005 | Jessye Norman |
| 9007 | Dame Joan Sutherland |
| 9011 | José van Dam |
| 9013 | Maria Callas |
| 9015 | Lötschberg 1913 |
| 9018 | Wilhelmenia Fernandez |
| 9022 | Dame Janet Baker |
| 9024 | Gotthard 1882 |
| 9026 | Furkatunnel 1982 |
| 9029 | Thomas Allen |
| 9033 | Montserrat Caballé |
| 9036 | Alain Fondary |
| 9037 | Gabriel Bacquier |
| 9801 | Lesley Garrett |
| 9802 | Stuart Burrows |
| 9803 | Benjamin Luxon |
| 9804 | Victoria de los Ángeles |
| 9806 | Régine Crespin |
| 9808 | Elisabeth Söderström |
| 9809 | Françoise Pollet |
| 9810 | Jean-Philippe Courtis |
| 9812 | Luciano Pavarotti |
| 9814 | Lucia Popp |
| 9816 | Willard White |
| 9819 | Maria Ewing |
| 9820 | Nicolai Ghiaurov |
| 9821 | Teresa Berganza |
| 9823 | Dame Elisabeth Schwarzkopf |
| 9825 | Jungfraujoch 1912 |
| 9827 | Barbara Hendricks |
| 9828 | Kiri Te Kanawa |
| 9831 | Plácido Domingo |
| 9832 | Renata Tebaldi |
| 9834 | Mirella Freni |
| 9835 | Nicolai Gedda |
| 9838 | Hildegard Behrens |